ZMM status failed

[Северный папуас]

А что это может быть такое - купили новый сервак, контроллер выдает такую ошибку.

[Северный папуас]

вот инфа о контролере

[Северный папуас]

и не могу на первый рейд систему поставить (win 2008 r2 64) неужели драйвера нужны - вообще не видит дисков

[Северный папуас]

Обновил биос матери + обновил контрллер = ZMM заработал и после пару перезагрузок диск сам нашелся ...

ломаю голову, его в продакшн отдавать что бы и как еще проверить, т.к. уедет он на север далеко ...

[Северный папуас]

Что за команда Clear ? Что она делает ?

Поставил все диски на верифи , на одном нашлись ошибки смарт - поставил CLEAR и вот всю ночь она уже с ним весит.

[LCF_R]

Команда Clear забивает диск нулями при создании массива.

[Северный папуас]

вот такие вот дела

Есть новый сервер следующей конфигурации:

№ Товар Кол-во
1 Материнская плата Supermicro X8DTi-F LGA1366<i5520>PCI-E+SVGA+2GbLAN SATA RAID E-ATX 12DDR-III, X8DTi-F
2 Сетевой адаптер Supermicro LAN 4-port AOC-SG-I4 (4-port Gigabit NIC Card), PCI-e x8, AOC-SG-i4
3 Процессор CPU Xeon X5650 LGA1366 (2.66/6.40GT/sec/12M) (SLBV3) OEM
4 Радиатор Supermicro SNK-P0038P 2U, LGA1366 Passive Heatsink, SNK-P0038P
5 Корпус Supermicro CSE-836E16-R1200B (Black) 3U Rack, 16x3.5"SAS2/SATA HSW, Expander, 1200W 1+1, CSE-836E16-R1200B
6 Модуль памяти DIMM DDR3 (1333) 8Gb ECC REG Parity Kingston KVR1333D3D4R9S/8G Retail, KVR1333D3D4R9S/8G 12 шт
7 Контроллер-Raid Adaptec ASR-6405 (PCI-E v2 x8, LP) SGL SAS 6G, RAID 0,1,10,5,6,50, 4port(intSFF8087), 512Mb onboard, ASR-6405
8 Батарея аварийного питания кэш-памяти Adaptec AFM-600 Kit, AFM-600 Kit
9 Винчестер HDD Hitachi Ultrastar 15K600, 300Gb, SAS, 15000 rpm, 64Mb, 0B23661/HUS156030VLS600 14 шт
10 Твердотельный накопитель Intel 2.5" 64Gb Intel® X25-E SSD SATA (SSDSA2SH064G101) SLC Chip, толщина 7mm, 50nm, OEM, SSDSA2SH064G1 2 шт
11 Кабель Supermicro CBL-0281L SFF 8087 to SFF 8087, 75cm, CBL-0281L 1 шт
12 Салазки SUPERMICRO 2.5" HDD Tray in 4th Generation 3.5" Hot Swap Tray, MCP-220-00043-0N 2 шт

Запустили. Сервер не видел один диск САС и "батарейку" выдавал ZMM failed. Поменяли диск + перепрошили биос матери и весь рейд. Создал один массив и установил туда ОС. Через сутки получил ошибку сарт на одном из 12 незадейственных дисков и через пару часов он отвалился совсем

Сервак уже отдавать надо - что это такое может с ним быть и что можно сделать ?

Вот логи рейда:

18 Декабрь 2011 г. 13:10:59 MSK

Configuration summary
---------------------------

Server name.....................WIN-1NT83D2A7Q7
Adaptec Storage Manager agent...7.30.00 (18837)
Adaptec Storage Manager console.7.30.00 (18837)
Number of controllers...........1
Operating system................Windows

Configuration information for controller 1
-------------------------------------------------------
Type............................Controller
Model...........................Adaptec 6405
Controller number...............1
Physical slot...................2
Installed memory size...........512 MB
Serial number...................1B3411BAD76
Boot ROM........................5.2-0 (18668)
Firmware........................5.2-0 (18668)
Device driver...................5.2-0 (18668)
Controller status...............Optimal
ZMM status......................Optimal
Background consistency check....Disabled
Copy back.......................Disabled
Controller temperature..........Normal (53C / 127F)
Default logical drive task priorityHigh
Performance mode................Dynamic
Number of logical devices.......1
Number of hot-spare drives......0
Number of ready drives..........14
NCQ status......................Enabled
Stay awake status...............Disabled
Internal drive spinup limit.....0
External drive spinup limit.....0
Statistics version..............3.0
SSD Cache size..................0
Pages on fetch list.............0
Fetch list candidates...........0
Candidate replacements..........0
Pages on dirty list.............0
Pages on failed list............0
59304...........................9366

Logical device..................0
Logical device name.............SYSTEM
RAID level......................1
Data space......................278,99 GB
Mirror space....................278,99 GB
Date created....................12/17/2011
Interface type..................Serial attached SCSI
State...........................Optimal
Additional details..............Quick initialized
Read-cache mode.................Enabled
Write-cache mode................Disabled (write-through)
Write-cache setting.............Disabled (write-through)
Partitioned.....................Yes
Protected by hot spare..........No
Bootable........................Yes
Bad stripes.....................No
Power Status....................Disabled
Power State.....................Active
Reduce RPM timer................Never
Power off timer.................Never
Verify timer....................Never
Segment 0.......................Present: controller 1, enclosure 0, slot 0, S/N J0VXU7YN
Segment 1.......................Present: controller 1, enclosure 0, slot 1, S/N J0VXUVBN
Overall host IOs................35116
Overall MB......................1551102
DRAM cache hits.................27029
SSD cache hits..................0
Uncached IOs....................7932
Overall disk failures...........0
DRAM cache full hits............27029
DRAM cache fetch / flush wait...0
DRAM cache hybrid reads.........1005
DRAM cache flushes..............--
Read hits.......................0
Write hits......................0
Valid Pages.....................0
Updates on writes...............0
Invalidations by R/W balance....0
Invalidations by replacement....0
Invalidations by other..........0
Page Fetches....................0
SSD page direct allocations.....0
SSD invalidations by full stripe size0
SSD flushes.....................0
0...............................0
3217............................1443
2945............................5835
4197............................19087
0...............................0
16845...........................139
3352............................24
1449............................1602
1444............................630

Serial attached SCSI
-----------------------
Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0VXU7YN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........8
World-wide name.................5000CCA01F3464CF
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 0
Negotiated transfer speed.......6.00 Gb/s
State...........................Optimal
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0VXUVBN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........9
World-wide name.................5000CCA01F346DBB
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 1
Negotiated transfer speed.......6.00 Gb/s
State...........................Optimal
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................INTEL
Model...........................SSDSA2SH064G1GC
Serial Number...................CVEM12160090064KGN
Firmware level..................045C8860
Reported channel................0
Reported SCSI device ID.........10
Interface type..................Serial ATA
Size............................59,626 GB
Location........................Enclosure 0, slot 2
Negotiated transfer speed.......3.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).true
NCQ status......................Enabled
Media Wearout indicator ( 0,000000e+00ft)99
Longevity: Based on PowerOnHours (hrs)2772.0
Longevity: Based on FutureWrites (GB)683.71875
Phy 0...........................3.00 Gb/s
0x03............................Spin-Up Time in millisecs
0x04............................Start/Stop Count
0x05............................Reallocated Sectors Count
0x09............................Power-On Hours
0x0C............................Power Cycle Count
0xC0............................Power-off Retract Count
0xE8............................Available Reserved Space
0xE9............................Media Wearout Indicator
0xE1............................Host Writes in Gigabytes
0xE2............................Load In-time
0xE3............................Torque Amplification Count
0xE4............................Power-Off Retract Cycle
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................INTEL
Model...........................SSDSA2SH064G1GC
Serial Number...................CVEM12140014064KGN
Firmware level..................045C8860
Reported channel................0
Reported SCSI device ID.........11
Interface type..................Serial ATA
Size............................59,626 GB
Location........................Enclosure 0, slot 3
Negotiated transfer speed.......3.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).true
NCQ status......................Enabled
Media Wearout indicator ( 0,000000e+00ft)99
Longevity: Based on PowerOnHours (hrs)2772.0
Longevity: Based on FutureWrites (GB)683.71875
Phy 0...........................3.00 Gb/s
0x03............................Spin-Up Time in millisecs
0x04............................Start/Stop Count
0x05............................Reallocated Sectors Count
0x09............................Power-On Hours
0x0C............................Power Cycle Count
0xC0............................Power-off Retract Count
0xE8............................Available Reserved Space
0xE9............................Media Wearout Indicator
0xE1............................Host Writes in Gigabytes
0xE2............................Load In-time
0xE3............................Torque Amplification Count
0xE4............................Power-Off Retract Cycle
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0VXUHHN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........12
World-wide name.................5000CCA01F346877
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 4
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................Yes
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............1
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................5
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0V31JJN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........13
World-wide name.................5000CCA01F058B7B
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 5
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0V0AGGN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........14
World-wide name.................5000CCA01F009D2B
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 6
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0V1DNBS
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........15
World-wide name.................5000CCA01F028F8B
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 7
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0V30J0N
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........16
World-wide name.................5000CCA01F057C37
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 8
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................JXYV9KBN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........17
World-wide name.................5000CCA018D8F033
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 9
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0V30JSN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........18
World-wide name.................5000CCA01F057C93
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 10
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0VX5MEN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........19
World-wide name.................5000CCA01F333E0F
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 11
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................JXYVADVN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........20
World-wide name.................5000CCA018D8FD07
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 12
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0V30XEN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........21
World-wide name.................5000CCA01F05823B
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 13
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0V30G6N
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........22
World-wide name.................5000CCA01F057B57
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 14
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Type............................Disk drive
Vendor..........................HITACHI
Model...........................HUS156030VLS600
Serial Number...................J0V30WXN
Firmware level..................A5D0
Reported channel................0
Reported SCSI device ID.........23
World-wide name.................5000CCA01F0581FB
Interface type..................Serial attached SCSI
Size............................279,461 GB
Location........................Enclosure 0, slot 15
Negotiated transfer speed.......6.00 Gb/s
State...........................Ready
S.M.A.R.T. error................No
Write-cache mode................Write back
Hardware errors.................0
Medium errors...................0
Parity errors...................0
Link failures...................0
Aborted commands................0
S.M.A.R.T. warnings.............0
Solid-state disk (non-spinning).false
Phy 0...........................6.00 Gb/s
Phy 1...........................No device attached
Power State.....................Full rpm
Supported power states..........Full rpm, Powered off
Aborted commands................0
Link failures...................0
Medium errors...................0
Parity errors...................0
Hardware errors.................0
SMART errors....................0

Serial attached SCSI
-----------------------
Type............................Enclosure management device
Vendor..........................LSI CORP
Model...........................SAS2X28
Firmware level..................0717
Enclosure status................Optimal
Fan 1 status....................Not installed
Fan 2 status....................Not installed
Fan 3 status....................Not installed
Fan 4 status....................Unknown
Fan 5 status....................Unknown
Power supply 1 status...........Not installed
Power supply 2 status...........Not installed
Temperature sensor 1 status.....Normal (28C / 82F)
Speaker status..................Off


End of the configuration information for controller 1
-------------------------------------------------------


Проблемный диск в 4ом слоте (в логе он есть, после того как пропал - его вообще не видит).

Сейчас запущу память протестировать, но вообще не нравится что отваливаются диски Может они не совместимы

Может что то в биосе или в настройках выставлено не так ? (все стоит по дефолту)

[brass]

Проблемный диск в 4ом слоте (в логе он есть, после того как пропал - его вообще не видит).

А если его в другой слот воткнуть - тоже не видится?

Сейчас запущу память протестировать, но вообще не нравится что отваливаются диски Может они не совместимы

А в HCL лист заглядывали перед покупкой?